Safety Data Sheet Revision Number: 001.7 Issue date: 10/28/2014 IDH number: 504469 Product name: Loctite Silver Anti-Seize Page 1 of 6 1. PRODUCT AND COMPANY IDENTIFICATION Product name: Loctite Silver Anti-Seize IDH number: 504469 Product type: Lubricant Item number: 37617 Restriction of Use: None identified Region: United States Company address: Contact information: Henkel Corporation One Henkel Way Rocky Hill, Connecticut 06067 Telephone: (860) 571-5100 MEDICAL EMERGENCY Phone: Poison Control Center 1-877-671-4608 (toll free) or 1-303-592-1711 TRANSPORT EMERGENCY Phone: CHEMTREC 1-800-424-9300 (toll free) or 1-703-527-3887 Internet: www.henkelna.com 2. HAZARDS IDENTIFICATION EMERGENCY OVERVIEW DANGER: CAUSES SEVERE SKIN BURNS AND EYE DAMAGE. HAZARD CLASS HAZARD CATEGORY SKIN CORROSION 1C SERIOUS EYE DAMAGE 1 PICTOGRAM(S) Precautionary Statements Prevention: Do not breathe dust or fumes. Wash thoroughly after handling. Wear protective gloves, eye protection, and face protection. Response: IF SWALLOWED: Rinse mouth. Do NOT induce vomiting. If on skin (or hair): Take off immediately all contaminated clothing. IF INHALED: Remove person to fresh air and keep comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to remove. Continue rinsing. Immediately call a poison control center or physician. Wash contaminated clothing before reuse. Storage: Store locked up. Disposal: Dispose of contents and/or container according to Federal, State/Provincial and local governmental regulations. Classification complies with OSHA Hazard Communication Standard (29 CFR 1910.1200) and is consistent with the provisions of the United Nations Globally Harmonized System of Classification and Labeling of Chemicals (GHS). See Section 11 for additional toxicological information. 3. COMPOSITION / INFORMATION ON INGREDIENTS Hazardous Component(s) CAS Number Percentage* Distillates (petroleum), hydrotreated heavy naphthenic 64742-52-5 10 - 30 IDH number: 504469 Product name: Loctite Silver Anti-Seize Page 2 of 6 Petroleum distillates, hydrotreated, light naphthenic 64742-53-6 10 - 30 Graphite 7782-42-5 10 - 30 Calcium oxide 1305-78-8 10 - 30 Aluminum not powder, dust or fume 7429-90-5 5 - 10 Distillates (petroleum), straight-run middle 64741-44-2 1 - 5 * Exact percentage is a trade secret. Concentration range is provided to assist users in providing appropriate protections. 4. FIRST AID MEASURES Inhalation: Move to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical attention. Skin contact: Remove contaminated clothing and footwear. Immediately flush skin with plenty of water (using soap, if available). Get medical attention. Wash clothing before reuse. Eye contact: Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. Get medical attention. Ingestion: Do not induce vomiting. Aspiration may cause pulmonary edema and pneumonitis. Never give anything by mouth to an unconscious person. Get medical attention. Symptoms: See Section 11. 5. FIRE FIGHTING MEASURES Extinguishing media: Carbon dioxide. Dry chemical. Foam Special firefighting procedures: Wear self-contained breathing apparatus and full protective clothing, such as turn-out gear. In case of fire, keep containers cool with water spray. Unusual fire or explosion hazards: None Hazardous combustion products: Oxides of carbon. 6. ACCIDENTAL RELEASE MEASURES Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected personnel. Environmental precautions: Do not allow product to enter sewer or waterways. Clean-up methods: Scrape up as much material as possible. Clean residue with soap and water. Store in a closed container until ready for disposal. 7. HANDLING AND STORAGE Handling: Use only with adequate ventilation. Prevent contact with eyes, skin and clothing. Do not breathe vapor and mist. Wash thoroughly after handling. Keep container closed. Storage: Keep in a cool, well ventilated area. For information on product shelf life contact Henkel Customer Service at (800) 243-4874. IDH number: 504469 Product name: Loctite Silver Anti-Seize Page 3 of 6 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure controls and protective equipment for each task performed. Hazardous Component(s) ACGIH TLV OSHA PEL AIHA WEEL OTHER Distillates (petroleum), hydrotreated heavy naphthenic 5 mg/m3 TWA mist 10 mg/m3 STEL mist 5 mg/m3 TWA mist 500 ppm (2,000 mg/m3) PEL 5 mg/m3 PEL Mist. None None Petroleum distillates, hydrotreated, light naphthenic None 500 ppm (2,000 mg/m3) PEL 5 mg/m3 PEL Mist. None None Graphite 2 mg/m3 TWA Respirable fraction. 5 mg/m3 PEL Respirable fraction. 15 mg/m3 PEL Total dust. 15 MPPCF TWA None None Calcium oxide 2 mg/m3 TWA 5 mg/m3 PEL None None Aluminum not powder, dust or fume None None None None Distillates (petroleum), straight-run middle 5 mg/m3 TWA mist 10 mg/m3 STEL mist 5 mg/m3 TWA mist None None Engineering controls: Use only with adequate ventilation. Local exhaust ventilation is recommended when general ventilation is not sufficient to control airborne contamination below occupational exposure limits. Respiratory protection: If personal exposure cannot be controlled below applicable limits by ventilation, wear a properly fitted organic vapor/particulate respirator approved by NIOSH. Observe OSHA regulations for respirator use (29 CFR 1910.134). Respirator with combination filter for vapor/particulate. Eye/face protection: Safety goggles or safety glasses with side shields. Safety showers and eye wash stations should be available. Skin protection: Use chemical resistant, impermeable clothing including gloves and either an apron or body suit to prevent skin contact. Neoprene, Butyl-rubber, or nitrile- rubber gloves. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical state: Solid Color: Silver Odor: Mild Odor threshold: Not available. pH: Not applicable Vapor pressure: Not determined Boiling point/range: Not available. Melting point/ range: Not available. Specific gravity: 1.10 Vapor density: Not determined Flash point: Product is a solid. Burn Rate: Approx 12 mm/2 minutes Flammable/Explosive limits - lower: Not determined Flammable/Explosive limits - upper: Not determined Autoignition temperature: Not determined Evaporation rate: Not determined Solubility in water: Insoluble Partition coefficient (n-octanol/water): Not determined VOC content: < 3 % Viscosity: Not available. Decomposition temperature: Not available. IDH number: 504469 Product name: Loctite Silver Anti-Seize Page 4 of 6 10. STABILITY AND REACTIVITY Stability: Stable under normal conditions of storage and use. Hazardous reactions: Will not occur. Hazardous decomposition products: Oxides of carbon. Incompatible materials: Oxidizing agents. Reactivity: Not available. Conditions to avoid: Keep away from heat, spark and flame. 11. TOXICOLOGICAL INFORMATION Relevant routes of exposure: Skin, Inhalation, Eyes Potential Health Effects/Symptoms Inhalation: May cause respiratory tract irritation. Skin contact: Causes skin burns. Eye contact: Causes serious eye damage. Ingestion: Ingestion may cause gastrointestinal irritation, nausea, vomiting and diarrhea. Principal hazard of ingestion is aspiration into the lungs and subsequent pneumonitis. Hazardous Component(s) LD50s and LC50s Immediate and Delayed Health Effects Distillates (petroleum), hydrotreated heavy naphthenic None Irritant Petroleum distillates, hydrotreated, light naphthenic None Irritant Graphite None Lung Calcium oxide None Irritant, Corrosive, Eyes Aluminum not powder, dust or fume None Central nervous system, Irritant, Lung Distillates (petroleum), straight-run middle None Irritant Hazardous Component(s) NTP Carcinogen IARC Carcinogen OSHA Carcinogen (Specifically Regulated) Distillates (petroleum), hydrotreated heavy naphthenic No No No Petroleum distillates, hydrotreated, light naphthenic No No No Graphite No No No Calcium oxide No No No Aluminum not powder, dust or fume No No No Distillates (petroleum), straight-run middle No No No 12. ECOLOGICAL INFORMATION Ecological information: Not available. IDH number: 504469 Product name: Loctite Silver Anti-Seize Page 5 of 6 13. DISPOSAL CONSIDERATIONS Information provided is for unused product only. Recommended method of disposal: Follow all local, state, federal and provincial regulations for disposal. Hazardous waste number: Not a RCRA hazardous waste. 14. TRANSPORT INFORMATION The transport information provided in this section only applies to the material/formulation itself, and is not specific to any package/configuration. U.S. Department of Transportation Ground (49 CFR) Proper shipping name: Not regulated Hazard class or division: None Identification number: None Packing group: None International Air Transportation (ICAO/IATA) Proper shipping name: Not regulated Hazard class or division: None Identification number: None Packing group: None Water Transportation (IMO/IMDG) Proper shipping name: Not regulated Hazard class or division: None Identification number: None Packing group: None 15. REGULATORY INFORMATION United States Regulatory Information TSCA 8 (b) Inventory Status: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory. TSCA 12 (b) Export Notification: None above reporting de minimis CERCLA/SARA Section 302 EHS: None above reporting de minimis CERCLA/SARA Section 311/312: Immediate Health, Delayed Health CERCLA/SARA Section 313: None above reporting de minimis California Proposition 65: No California Proposition 65 listed chemicals are known to be present. Canada Regulatory Information CEPA DSL/NDSL Status: All components are listed on or are exempt from listing on the Canadian Domestic Substances List. 16. OTHER INFORMATION This safety data sheet contains changes from the previous version in sections: New Safety Data Sheet format. Prepared by: Lou Fabrizio, Regulatory Affairs Specialist Issue date: 10/28/2014 IDH number: 504469 Product name: Loctite Silver Anti-Seize Page 6 of 6 DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation and its affiliates (?Henkel?) does not assume responsibility for any results obtained by persons over whose methods Henkel has no control. It is the user?s responsibility to determine the suitability of Henkel?s products or any production methods mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be involved in the handling and use of any Henkel?s products. In light of the foregoing, Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel?s products. Henkel further disclaims any liability for consequential or incidental damages of any kind, including lost profits.